Emergency Care for Your Eyes and Face in a Workplace

Do you work in a place where you handle dangerous materials that can harm your eyes and face? Universally, occupational therapy standards demand workers use personal protective equipment such as safety goggles or eyeglasses from emergency eye wash station. However, in some cases, these options can fail. When that happens, the next best step is an emergency eye wash station. 

What is an eye wash station?

First off, an emergency eye wash station is a requirement by OSHA (Occupational Safety and Health Administration) in any workplace. The device gives workers the first opportunity to flush and wash their eyes and face in case of an injury. This should take place immediately, which is why the station should be very close to the workplace. According to OSHA standards, the station should be located between 82 and 96 inches in height from the work surface.

Types of eye wash stations

For an emergency eye wash station to remain effective, an injured person should flush and wash the eyes thoroughly for not less than fifteen minutes. The station comes with a special fluid for flushing the eyes under low pressure. It is advisable for an injured person to reach the station as fast as possible and wash the affected area thoroughly before the chemical can cause further damage. With adequate knowledge of the types of eye wash stations that are available in the market, you can make a wise selection when buying the devices. The following are recommended types of emergency eyewash stations:

  • Self-contained eyewash stations

Also known as portable eye wash stations, these devices don’t require plumbing. Professionals can install them on any wall at a relatively lower cost. Reliable companies that install eye wash stations can also install a general purpose spill kit. If you would like to know more about emergency shower stations, you should consult certified service providers.

The self-contained stations are perfect for places without adequate plumbing system. Based on their design, you can simply pull a handle to release the solution to flush the eyes. Besides, the design allows for hands-free operation once the device is on. You can, therefore, use the hands to open the eyes.

  • Plumbed eyewash stations

These types of stations are connected to a permanent water supply. According to OSHA regulations, they should be installed close to hazard-prone areas. The path leading to the station should also be clear to allow easy access to the point of help. If possible, an injured person should reach the station within ten seconds after injury. Like the self-contained models, they also give you the opportunity to use your hands to open your eyes for a thorough flush. Besides, you can use the station in conjunction with your personal eye wash solution.

The eyewash station, like any other device, requires maintenance. It is always advisable to involve a professional to provide a detailed safety shower inspection checklist. For example, the unit should be able to dispense the solution to both eyes simultaneously. The solution should also be at the right temperature, which is why monthly testing of the unit is equally important. Check out http://absorbenviro.com.au/emergency-shower-servicing/.

Share and Enjoy

  • Facebook
  • Twitter
  • Delicious
  • LinkedIn
  • StumbleUpon
  • Add to favorites
  • Email
  • RSS

Leave a Reply

Your email address will not be published. Required fields are marked *